David J. Gundlach

Using two layers of pentacene deposited at different substrate temperatures as the active material, we have fabricated photolithographically defined organic thin-film transistors (OTFTs) with improved field-effect mobility and subthreshold slope. These devices use photolithographically defined gold source and drain electrodes and octadecyltrichlorosilane-treated silicon dioxide gate dielectric. The devices have field-effect mobility as large as 1.5 cm/sup 2//V-s, on/off current ratio larger than 10/sup 8/, near zero threshold voltage, and subthreshold slope less than 1.6 V per decade. To our knowledge, this is the largest field-effect mobility and smallest subthreshold slope yet reported for any organic transistor, and the first time both of these important characteristics have been obtained for a single device.

The charge-carrier transport mechanism in the organic semiconductor pentacene is explored using thin-film transistor structures. The variation of the field-effect mobility with temperature differs from sample to sample, ranging from thermally activated to temperature-independent behavior. This result excludes thermally activated hopping as the fundamental transport mechanism in pentacene thin films, and suggests that traps and/or contact effects may strongly influence the observed characteristics. These results also indicate that field-effect transistors may not be appropriate vehicles for illuminating basic transport mechanisms in organic materials.

We have fabricated organic thin-film transistor (OTFT)-driven active matrix liquid crystal displays on flexible polymeric substrates. These small displays have 16×16 pixel polymer-dispersed liquid crystal arrays addressed by pentacene active layer OTFTs. The displays were fabricated using a low-temperature process (<110 °C) on flexible polyethylene naphthalate film and are operated as reflective active matrix displays.

Pentacene-based organic thin-film transistors (TFT's) with field-effect mobility as large as 0.7 cm/sup 2//V/spl middot/s and on/off current ratio larger than 10/sup 8/ have been fabricated. Pentacene films deposited by evaporation at elevated temperature at low-to-moderate deposition rates have a high degree of molecular ordering with micrometer-sized and larger dendritic grains. Such films yield TFT's with large mobility. Films deposited at low temperature or by flash evaporation have small grains and poor molecular ordering and yield TFT's with low mobility.

Abstract Parameters used to describe the electrical properties of organic field-effect transistors, such as mobility and threshold voltage, are commonly extracted from measured current–voltage characteristics and interpreted by using the classical metal oxide–semiconductor field-effect transistor model. However, in recent reports of devices with ultra-high mobility (>40 cm 2 V −1 s −1 ), the device characteristics deviate from this idealized model and show an abrupt turn-on in the drain current when measured as a function of gate voltage. In order to investigate this phenomenon, here we report on single crystal rubrene transistors intentionally fabricated to exhibit an abrupt turn-on. We disentangle the channel properties from the contact resistance by using impedance spectroscopy and show that the current in such devices is governed by a gate bias dependence of the contact resistance. As a result, extracted mobility values from d.c. current–voltage characterization are overestimated by one order of magnitude or more.